VCM-SF-30D/30C/30B-20臺灣ROSICO油泵電機VCM-SF-40D/40C/40B-20葉片泵

簡述液壓站10條操作注意事項，液壓操作工必看

 液壓站液壓系統操作注意事項。
液壓系統10條操作注意事項：
1、液壓系統運行后，檢查油箱油面，應不低于最低油位線；
2、首次運轉及長期停放后，運轉時不應滿載起動，應在低壓低速下進行一定時間的充分磨合運轉；
3、檢查各元件及接口的密封性，不得有滲漏現象；
4、系統使用轉速及工作壓力應不超過規定的額定值，不得在最高工作壓力下連續運轉；
5、滾筒調速及換向操作應緩慢，從一個方向轉換到另一個方向時，應在中位稍作停留，以免損壞換向機構和油泵；
6、一般工作油溫應在25℃ - 55℃，最高不超過80℃，低溫啓動時，應空負荷運轉10分鍾，待油溫升高后再帶負荷運轉；
7、系統運轉過程中如有異常噪聲和振動時，應立即停車檢查找出原因，排除故障后才能重新起動；
8、作業過程中隨時注意系統散熱情況，自動散熱系統如有故障，請打開電控箱上散熱器風扇開關強制散熱；
9、嚴寒季節作業低于0℃時，需要對液壓油進行加熱，自動控溫系統會自動打開加熱器電路給液壓油加熱，必須確認液壓油粘度合適時，才能啓動液壓系統開始工作，以免損壞系統元件，自動加熱系統如果出現故障，請打開電控箱上的開關強制加熱；
10、一般情況下，不要自行拆開液壓油泵 和馬達，如果發生故障，及時通知生産廠家維修。

柱塞泵：
P08-A0-F-R-01 P08-A1-F-R-01 P08-A2-F-R-01 P08-A3-F-R-01 P16-A0-F-R-01 P16-A1-F-R-01
P16-A2-F-R-01 P16-A3-F-R-01 P22-A0-F-R-01 P22-A1-F-R-01 P22-A2-F-R-01 P22-A3-F-R-01
P36-A0-F-R-01 P36-A1-F-R-01 P36-A2-F-R-01 P36-A3-F-R-01 P46-A0-F-R-01 P46-A1-F-R-01
P46-A2-F-R-01 P46-A3-F-R-01 P70-A4-F-R-01 P46-C2-D3-F-R P16-D3-FR-01  P46-A0/A1/A2/A3-F-R-01

1HP(750W臺灣電機） 2HP(1500W臺灣SY) 3HP（2200W電機）
ROP-10A ROP-10A（1/8接口） ROP-11A ROP-11A（1/4接口） ROP-11A（1/8接口） ROP-11A+1/4HP+風葉
ROP-11A-VB ROP-12A ROP-12A（1/4接口） ROP-12A+1/4HP+風葉 ROP-12A-VB ROP-13A ROP-13A(3/8接口）
ROP-13A+1/4HP+風葉 ROP-13A-VB
TK150-06 TK150-08 TK150-10 TK1510+1HP(750W) TK3015 TK-3015 TK-3015+1500W電機
TK-3015+750W電機 TK3020 TK-3020 TK-3020+1500W電機 TK-3020+2200W電機 TK3030
TK-3030 TK-3030+1500W電機 TK-3030+2200W電機 TK3040 TK-3040 TK-3040+2200W電機
TOP-203/204HB-VB TOP-203HB PT1/2 TOP-203HB-VB(VD) PT1/2 TOP-204HB PT1/2 TOP-204HB-VB(VD) PT1/2
TOP-206HB PT1/2 TOP-206HB-VB PT1/2 TOP-206HB-VB(VD) TOP-208HB PT1/2 TOP-208HB-VB(VD)
TOP-208HB-VB(VD) PT1/2 TOP-210HB PT3/4 TOP-210HB-VB(VD) TOP-210HB-VB(VD) PT3/4 TOP-212HB PT3/4
TOP-212HB-VB(VD) TOP-212HB-VB(VD) PT3/4 TOP-216HB PT3/4 TOP-216HB-VB(VD) TOP-216HB-VB(VD) PT3/4
TOP-220HB PT3/4 TOP-220HB-VB(VD) TOP-220HB-VB(VD) PT3/4
TOP2MY 1500電機 TOP2MY 200W電機 TOP2MY 400W電機 TOP2MY 750W電機 耐高溫ROP-11A 
定量葉片泵：
150T-48-FR 150T-61-FR 150T-75-FR 150T-94-FR 150T-116-FR 150T-125-FR 150T+150T
50T-07-FR 50T-12-FR 50T-14-FR 50T-17-FR 50T-19-FR 50T-20-FR 50T-23-FR 50T-25-FR
50T-26-FR 50T-28-FR 50T-30-FR 50T-36FR 50T-39-FR 50T-40-FR 
高壓葉片泵：
HVP-20-FA3 HVP-30-FA3 HVP-40-FA3 HVP-5440F-A3 HVP-0808F-A3 HVP-1212F-A3 HVP-1515F-A3
HVP-2020F-A3 HVP-3030F-A3 HVP-4040F-A3

PV2R1系列
PV2R1-10-F-RAA-41 PV2R1-10-F-RAB-41 PV2R1-10-F-RAL-41 PV2R1-10-F-RAR-41 PV2R1-10-L-RAA-41
PV2R1-10-L-RAB-41 PV2R1-10-L-RAL-41 PV2R1-10-L-RAR-41 PV2R1-12-F-RAA-41 PV2R1-12-F-RAB-41
PV2R1-12-F-RAL-41 PV2R1-12-F-RAR-41 PV2R1-12-L-RAA-41 PV2R1-12-L-RAB-41 PV2R1-12-L-RAL-41
PV2R1-12-L-RAR-41 PV2R1-14-F-RAA-41 PV2R1-14-F-RAB-41 PV2R1-17-F-RAA-41 PV2R1-19-F-RAA-41
PV2R1-31-F-RAA41 PV2R1-6-F-RAA-41 PV2R1-25-F-RAA-41
PV2R2系列：
PV2R2-26-F-RAA-41 PV2R2-26-F-RAB-41 PV2R2-26-F-RAL-41 PV2R2-26-F-RAR-41 PV2R2-26-L-RAA-41
PV2R2-26-L-RAB-41 PV2R2-26-L-RAL-41 PV2R2-26-L-RAR-41 PV2R2-33-F-RAA-41 PV2R2-33-F-RAB-41
PV2R2-33-F-RAL-41 PV2R2-33-F-RAR-41 PV2R2-33-L-RAA-41 PV2R2-33-L-RAB-41 PV2R2-33-L-RAL-41
PV2R2-33-L-RAR-41 PV2R2-41-F-RAA-41 PV2R2-41-F-RAB-41 PV2R2-41-F-RAL-41 PV2R2-41-F-RAR-41
PV2R2-41-L-RAA-41 PV2R2-41-L-RAB-41 PV2R2-41-L-RAL-41 PV2R2-41-L-RAR-41  PV2R2-47-F-RAA-41
PV2R2-47-F-RAB-41 PV2R2-47-F-RAL-41 PV2R2-47-F-RAR-41 PV2R2-47-L-RAA-41 PV2R2-47-L-RAB-41
PV2R2-47-L-RAL-41 PV2R2-47-L-RAR-41  PV2R2-53-F-RAA-41 PV2R2-53-F-RAB-41 PV2R2-53-F-RAL-41
PV2R2-53-F-RAR-41 PV2R2-53-L-RAA-41 PV2R2-53-L-RAB-41 PV2R2-53-L-RAL-41 PV2R2-53-L-RAR-41
PV2R2-59-F-RAA-41 PV2R2-59-F-RAB-41 PV2R2-65-F-RAA-41
PV2R3系列：
PV2R3-136-F-RAA-31  PV2R3-66-L-RAA-31 PV2R3-66-L-RAB-31 PV2R3-66-L-RAL-31 PV2R3-66-L-RAR-31
PV2R3-76-F-RAA-31 PV2R3-76-F-RAB-31 PV2R3-76-F-RAL-31 PV2R3-76-F-RAR-31 PV2R3-76-L-RAA-31
PV2R3-76-L-RAB-31 PV2R3-76-L-RAL-31 PV2R3-76-L-RAR-31 PV2R3-85-F-RAA-31 PV2R3-85-F-RAB-31
PV2R3-85-F-RAL-31 PV2R3-85-F-RAR-31 PV2R3-85-L-RAA-31 PV2R3-85-L-RAB-31 PV2R3-85-L-RAL-31
PV2R3-85-L-RAR-31 PV2R3-94-F-RAA-31 PV2R3-94-F-RAB-31 PV2R3-94-F-RAL-31 PV2R3-94-F-RAR-31
PV2R3-94-L-RAA-31 PV2R3-94-L-RAB-31 PV2R3-94-L-RAL-31 PV2R3-94-L-RAR-31
PV2R4系列：
PV2R4-136-F-RAA-30 PV2R4-153F-RAA-30 PV2R4-184F-RAA-30 PV2R4-200F-RAA-30 PV2R4-237F-RAA-30
PV2R4A-138-FRAA-10 PV2R4A-162-FRAA-10 PV2R4A-193-FRAA-10
PV2R11系列：
PV2R11-19/19F PV2R11-4-23-F-R-A PV2R11-12/12F PV2R11-31/12F1 PV2R11-4/4-F-RAA PV2R11-6/4-F-RAA
PV2R11-6/6-F-RAA PV2R11-8/4-F-RAA PV2R11-8/8-F-RAA PV2R11-10/4-F-RAA PV2R11-10/6-F-RAA
PV2R11-10/8-F-RAA PV2R11-10/10-F-RAA PV2R11-12/4-F-RAA PV2R11-12/6-F-RAA PV2R11-12/10-F-RAA
PV2R11-12/12-F-RAA PV2R11-16/6-F-RAA PV2R11-16/10-F-RAA PV2R11-20/6-F-RAA PV2R11-20/10-F-RAA
PV2R11-23/10-F-RAA
PV2R12系列：
PV2R12-10-26-F-REAA-41 PV2R12-10-26-L-REAA-41 PV2R12-10-33-F-REAA-41 PV2R12-10-33-L-REAA-41
PV2R12-10-41-F-REAA-41 PV2R12-10-41-L-REAA-41 PV2R12-10-47-F-REAA-41 PV2R12-10-47-L-REAA-41
PV2R12-10-53-F-REAA-41 PV2R12-10-53-L-REAA-41 PV2R12-10-59-F-REAA-41 PV2R12-10-59-L-REAA-41
PV2R12-10-65-F-REAA-41 PV2R12-10-65-L-REAA-41 PV2R12-12-26-F-REAA-41 PV2R12-12-26-L-REAA-41
PV2R12-12-33-F-REAA-41 PV2R12-12-33-L-REAA-41 PV2R12-12-41-F-REAA-41 PV2R12-12-41-L-REAA-41
PV2R12-12-47-F-REAA-41 PV2R12-12-47-L-REAA-41 PV2R12-12-53-F-REAA-41 PV2R12-12-53-L-REAA-41
PV2R12-12-59-L-REAA-41 PV2R12-12-65-L-REAA-41 PV2R12-14-26-L-REAA-41 PV2R12-14-33-L-REAA-41
PV2R12-14-41-L-REAA-41 PV2R12-14-47-L-REAA-41 PV2R12-14-53-L-REAA-41 PV2R12-14-59-L-REAA-41
PV2R12-14-65-L-REAA-41 PV2R12-17-26-L-REAA-41 PV2R12-17-33-L-REAA-41 PV2R12-17-41-L-REAA-41
PV2R12-17-47-L-REAA-41 PV2R12-17-53-L-REAA-41 PV2R12-17-59-L-REAA-41 PV2R12-17-65-L-REAA-41
PV2R12-19-26-L-REAA-41 PV2R12-19-33-L-REAA-41 PV2R12-19-41-L-REAA-41 PV2R12-19-47-L-REAA-41
PV2R12-19-53-L-REAA-41 PV2R12-25-47-F-REAA-41 PV2R12-25-53-F-REAA-41 PV2R12-25-59-F-REAA-41
PV2R12-25-65-F-REAA-41 PV2R12-31-26-F-REAA-41 PV2R12-31-33-F-REAA-41 PV2R12-31-41-F-REAA-41
PV2R12-31-47-F-REAA-41 PV2R12-31-53-F-REAA-41 PV2R12-31-59-F-REAA-41 PV2R12-31-65-F-REAA-41
PV2R12-6-26-F-REAA-41 PV2R12-6-26-L-REAA-41 PV2R12-6-33-F-REAA-41 PV2R12-6-33-L-REAA-41
PV2R12-6-41-F-REAA-41 PV2R12-6-41-L-REAA-41 PV2R12-6-47-F-REAA-41 PV2R12-6-47-L-REAA-41
PV2R12-6-53-F-REAA-41 PV2R12-6-53-L-REAA-41 PV2R12-6-59-F-REAA-41 PV2R12-6-59-L-REAA-41
PV2R12-6-65-F-REAA-41 PV2R12-6-65-L-REAA-41 PV2R12-8-26-F-REAA-41 PV2R12-8-26-L-REAA-41
PV2R12-8-33-F-REAA-41 PV2R12-8-33-L-REAA-41 PV2R12-8-41-F-REAA-41 PV2R12-8-41-L-REAA-41
PV2R12-8-47-F-REAA-41 PV2R12-8-47-L-REAA-41 PV2R12-8-53-F-REAA-41 PV2R12-8-53-L-REAA-41
PV2R12-8-59-F-REAA-41 PV2R12-8-59-L-REAA-41 PV2R12-8-65-F-REAA-41 PV2R12-8-65-L-REAA-41
PV2R13系列：
PV2R13-31/94-F-R
PV2R21系列：
PV2R21-53/31RAFF1 PV2R21-33/19 PV2R21-75/31RAFF1 PV2R21-33/30FR PV2R21-41/17-FR PV2R21-41/19-FR
PV2R23系列
PV2R23-75-153-F-RAAA-41 PV2R23-75-200-F-RAAA-41 PV2R23-41/116-F-R PV2R23-65-94-L-REAA-41
PV2R23-65/94-F-R PV2R23/116-53-F-R
PV2R24系列：
PV2R24-26-136-F-RAAA-41 PV2R24-26-153-F-RAAA-41 PV2R24-26-184-F-RAAA-41 PV2R24-26-200-F-RAAA-41
PV2R24-26-237-F-RAAA-41 PV2R24-33-136-F-RAAA-41 PV2R24-33-153-F-RAAA-41 PV2R24-33-184-F-RAAA-41
PV2R24-33-200-F-RAAA-41 PV2R24-33-237-F-RAAA-41 PV2R24-41-136-F-RAAA-41 PV2R24-41-153-F-RAAA-41
PV2R24-41-153-F-REAA-40 PV2R24-41-184-F-RAAA-41 PV2R24-41-184-F-REAA-40 PV2R24-41-200-F-RAAA-41
PV2R24-41-200-F-REAA-40 PV2R24-41-237-F-RAAA-41 PV2R24-41-237-F-REAA-40 PV2R24-47-136-F-RAAA-41
PV2R24-47-136-F-REAA-40 PV2R24-47-153-F-RAAA-41 PV2R24-47-153-F-REAA-40 PV2R24-47-184-F-RAAA-41
PV2R24-47-184-F-REAA-40 PV2R24-47-200-F-RAAA-41 PV2R24-47-200-F-REAA-40 PV2R24-47-237-F-RAAA-41
PV2R24-47-237-F-REAA-40 PV2R24-53-136-F-RAAA-41 PV2R24-53-136-F-REAA-40 PV2R24-53-153-F-RAAA-41
PV2R24-53-153-F-REAA-40 PV2R24-53-184-F-RAAA-41 PV2R24-53-184-F-REAA-40 PV2R24-53-200-F-RAAA-41
PV2R24-53-200-F-REAA-40 PV2R24-53-237-F-RAAA-41 PV2R24-53-237-F-REAA-40 PV2R24-59-136-F-RAAA-41
PV2R24-59-136-F-REAA-40 PV2R24-59-153-F-RAAA-41 PV2R24-59-153-F-REAA-40 PV2R24-59-184-F-RAAA-41
PV2R24-59-184-F-REAA-40 PV2R24-59-200-F-RAAA-41 PV2R24-59-200-F-REAA-40 PV2R24-59-237-F-RAAA-41
PV2R24-59-237-F-REAA-40 PV2R24-65-136-F-RAAA-41 PV2R24-65-136-F-REAA-40 PV2R24-65-153-F-RAAA-41
PV2R24-65-153-F-REAA-40 PV2R24-65-184-F-RAAA-41 PV2R24-65-184-F-REAA-40 PV2R24-65-200-F-RAAA-41
PV2R24-65-200-F-REAA-40 PV2R24-65-237-F-REAA-40 PV2R24-75-136-F-RAAA-41 PV2R24A-41-FRAAA-10
PV2R34A-76-FRAAA-10
PV2R32系列：
PV2R32-52/26-F-R PV2R32-60/33-F-R PV2R32-66/41-F-R PV2R32-76/47-F-R PV2R32-94/53-F-R
PV2R32-116/59-F-R PV2R32-125/65-F-R PV2R32-136/70-F-R 

VPVC-F12-A1-02A/03A/04A VPVC-F12-A2-02A/03A/04A VPVC-F12-A3-02A/03A/04A VPVC-F12-A4-02A/03A/04A
VPVC-F20-A1-02A/03A/04A VPVC-F20-A2-02A/03A/04A VPVC-F20-A3-02A/03A/04A VPVC-F20-A4-02A/03A/04A
VPVC-F30-A1-02A/03A/04A VPVC-F30-A2-02A/03A/04A VPVC-F30-A3-02A/03A/04A VPVC-F30-A4-02A/03A/04A
VPVC-F40-A1-02A/03A/04A VPVC-F40-A2-02A/03A/04A VPVC-F40-A3-02A/03A/04A VPVC-F40-A4-02A/03A/04A

VPNC-F07-2-30 VPNC-F12-2-30 VPNC-F14-2-30 VPNC-F17-2-30 VPNC-F19-2-30 VPNC-F21-2-30 VPNC-F23-2-30
VPNC-F26-2-30 VPNC-F30-2-30 VPNC-F36-2-30 VPNC-F40-2-30 VPNE-F48-2-30 VPNE-F61-2-30 VPNE-F75-2-30
VPNE-F94-2-30 VPNE-F116-2-30

VCM-SF-12A-10 VCM-SF-12B-10 VCM-SF-12C-10 VCM-SF-12D-10 VCM-SF-15A-10 VCM-SF-15B-10
VCM-SF-15C-10 VCM-SF-15D-10 VCM-SF-20A-10 VCM-SF-20B-10 VCM-SF-20C-10 VCM-SF-20D-10
VCM-SF-30A-10 VCM-SF-30B-10 VCM-SF-30C-10 VCM-SF-30D-10 VCM-SF-40A-10 VCM-SF-40B-10
VCM-SF-40C-10 VCM-SF-40D-10